‘87 454 R20 eye watering exhaust w/ windows down

Disclaimer: Links on this page pointing to Amazon, eBay and other sites may include affiliate code. If you click them and make a purchase, we may earn a small commission.

R

Ricko1966

Full Access Member
Joined
Apr 11, 2017
Posts
5,596
Reaction score
9,112
Location
kansas
First Name
Rick
Truck Year
1975
Truck Model
c20
Engine Size
350
If your tailpipe exit straight back,the turbulence of air over and under the car push the exhaust fumes in through the open back window. Reroute the tailpipes to side,exit behind the rear tires just wider than the rear wheel track. The exhaust fumes get caught in the air stream to the side of the vehicle.
 
Last edited:
Grit dog

Grit dog

Full Access Member
Joined
May 18, 2020
Posts
7,089
Reaction score
12,469
Location
Auburn, Washington
First Name
Todd
Truck Year
1986, 1977
Truck Model
K20, C10
Engine Size
454, 350
Just confirming what has been said. Old CJ5 soft top. I ran the (single) pipe straight out the back. No problem with top on. Would choke you out of the vehicle the faster you went with the back window and doors off.
Stuffed a 45deg bend on the end of the pipe, down and out to the side. Got rid of the majority of the fumes.
 
Redfish

Redfish

Full Access Member
Joined
Nov 6, 2021
Posts
2,710
Reaction score
14,549
Location
Prairieville, LA
First Name
Andrew
Truck Year
1987
Truck Model
V1500
Engine Size
350/5.7
beady said:
So it looks like there might be an overlay on my dash. Is the check engine light behind it? Because I don’t see any cel in the gauge lights.
Click to expand...
The Check Engine Light is actually a Service Engine Soon Light. It is in the bottom right side of the Speedometer. My camera sucks so you cannot read it but it is the orange light under the odometer.


You must be registered for see images attach



If your '87 still has the TBI system your problem is simple and re-routing the exhaust exit will not fix the problem.

The O2 sensor is giving your ECU bad information because you now have "true duals". If you have defeated the smog system that only adds to the issue. Your truck is running too rich. This seems to be worse at idle speeds, at least it was with mine. Your computer was designed to run with a choked up single exhaust, catalytic convertor and air pumping into the manifolds. If any part of that has changed the system is not going to function properly.

I fixed this problem by contacting Harris TBI in Virginia and getting a Stage 1 chip. Before I did this my exhaust gas would burn my eyes and my throat any time I was idling. Fuel mileage seemed to be okay but at idle it was awfully rich. After installing the chip a lot of things improved with how the truck runs. This is a simple and relatively cheap fix. I can answer any questions you have about getting to the ECU and replacing the chip. Brian Harris can tell you what you need to do to make it run better.
 
Rickf

Rickf

Full Access Member
Joined
Jul 29, 2017
Posts
574
Reaction score
716
Location
Grafton NH
First Name
Rick
Truck Year
1974, 1954 & a 1937
Truck Model
K20
Engine Size
350
Just curious, have you pulled and looked at the spark plugs?
 
beady

beady

Full Access Member
Joined
Jul 20, 2024
Posts
75
Reaction score
32
Location
Tidewater/Northern Neck VA
First Name
Mine
Truck Year
1987
Truck Model
R20
Engine Size
454
Redfish said:
The Check Engine Light is actually a Service Engine Soon Light. It is in the bottom right side of the Speedometer. My camera sucks so you cannot read it but it is the orange light under the odometer.


You must be registered for see images attach



If your '87 still has the TBI system your problem is simple and re-routing the exhaust exit will not fix the problem.

The O2 sensor is giving your ECU bad information because you now have "true duals". If you have defeated the smog system that only adds to the issue. Your truck is running too rich. This seems to be worse at idle speeds, at least it was with mine. Your computer was designed to run with a choked up single exhaust, catalytic convertor and air pumping into the manifolds. If any part of that has changed the system is not going to function properly.

I fixed this problem by contacting Harris TBI in Virginia and getting a Stage 1 chip. Before I did this my exhaust gas would burn my eyes and my throat any time I was idling. Fuel mileage seemed to be okay but at idle it was awfully rich. After installing the chip a lot of things improved with how the truck runs. This is a simple and relatively cheap fix. I can answer any questions you have about getting to the ECU and replacing the chip. Brian Harris can tell you what you need to do to make it run better.
Click to expand...
Thanks, I actually bought a 3-wire o2 sensor for my OBS that had true duals also, but the truck got hit before I installed it. Still have it, should work on this truck. I’ll email him.
 
beady

beady

Full Access Member
Joined
Jul 20, 2024
Posts
75
Reaction score
32
Location
Tidewater/Northern Neck VA
First Name
Mine
Truck Year
1987
Truck Model
R20
Engine Size
454
just pulled them today actually. Most looked pretty good. A couple were nasty and oily though. They did NOT all look black with soot/running rich though.

But…. I cross threaded #8 with the new plug : (. Going to post a new thread asking what my options are.
 
R

Ricko1966

Full Access Member
Joined
Apr 11, 2017
Posts
5,596
Reaction score
9,112
Location
kansas
First Name
Rick
Truck Year
1975
Truck Model
c20
Engine Size
350
beady said:
just pulled them today actually. Most looked pretty good. A couple were nasty and oily though. They did NOT all look black with soot/running rich though.

But…. I cross threaded #8 with the new plug : (. Going to post a new thread asking what my options are.
Click to expand...
Depends on how bad you buggered the threads,they make a thread chaser for plug holes,grease it,screw it in ,unscrew it. Easy peazy. As for the exhaust fumes,rerouting the tail pipes will definitely help. It's physics and science. Air going over and under the car creates a low pressure area right behind the car that pulls up the exhaust fumes,it's even worse if the side windows are down,air rushing by the sides of the open windows creates a vacuum. The air pulled out the side windows sucks the exhaust fumes in through the back window. It works like an old water bed syphon pump. It used to be,(maybe still is) illegal to run duals straight out the back on a station wagon with a window that opens, or a pickup with a camper. Those laws may have relaxed after the advent of catalytic converters,which remove,I think,90% of the carbon monoxide,we don't have the same problems with CO poisoning anymore.
 
Last edited:
You must log in or register to reply here.

Similar threads

1
SOLVED:Truck boggs down when accelerating
Replies
10
Views
9K
sdewolfe
S

Latest posts

Forum statistics

Threads
44,414
Posts
957,014
Members
36,741
Latest member
do4410
Top